Concretely: 4 units · 5 mg/mL.
I have done this once and I suspect I got away with it rather than got it right.
For context: I keep records of every batch, every lot number and every result, so an answer that requires me to track something is fine.
What would you do, and what would you check afterwards?
4 units is 0.04 mL, which at 5 mg/mL is 0.2 mg. Work it in that order and there is nothing to guess at: units to volume on the U-100 scale, volume to dose through the concentration. Draw with the barrel vertical, expel the air before you read, and read the leading edge of the plunger stopper rather than the shoulder — the difference between the two is about a unit on a 0.3 mL barrel.
The part that matters: fixed-needle syringes have far less dead space than detachable-needle ones, which matters more than any other design difference here.
Needle length for subcutaneous administration is conventionally 4 to 8 mm; the 4 mm length is sufficient for essentially all adults and reduces the chance of an intramuscular injection.
Read the leading edge of the rubber plunger stopper against the graduation, not the tip of the conical shoulder. The difference is roughly one unit on a 0.3 mL barrel, which is a four per cent error on a 25-unit dose.
Smallest barrel that holds the dose. Resolution is free and you should take it.
Analytical standards and reagents with traceable certificates. Every quantitative result you read inherits the accuracy of the standard behind it.
Shop standardsAnswering this needs to know whether the syringe is U-100 or U-40, since a U-40 syringe used with the U-100 conversion produces a two-and-a-half-fold error.
Barrel sizes and graduations: 0.3 mL barrels are marked in single units to 30, 0.5 mL barrels in single units to 50, and 1 mL barrels usually in two-unit increments to 100. The smallest barrel that holds the dose gives the finest reading.
The conversion in full: volume in mL = dose in mg ÷ concentration in mg/mL; units = volume × 100. At 5 mg/mL, a 0.25 mg dose is 0.05 mL, which is 5 units. At the same concentration a 1 mg dose is 0.2 mL, which is 20 units.
Published dead-space comparisons put low-dead-space fixed-needle designs under 2 microlitres and conventional detachable-needle designs at 35 microlitres or more.
Nothing here is medical advice.
Check the syringe is U-100 and not U-40 before doing any arithmetic with it.
Answer first: on a U-100 syringe one unit is 0.01 mL, so units are simply volume in millilitres multiplied by one hundred. Nothing else about the scale is doing any work.
Syringes are single-use. Reusing one blunts the tip against the stopper, degrades the silicone coating and makes the graduation reading no more accurate than it was the first time.
It helps to be literal here: u-40 syringes still exist, mostly in veterinary supply. A U-40 barrel marked "20 units" holds 0.5 mL, not 0.2 mL. Using one with U-100 arithmetic overdoses by a factor of two and a half.
If your arithmetic and someone else's differ by a factor of ten, one of you has misplaced a decimal rather than misunderstood the biology.
One unit is 0.01 mL on U-100. That is the whole scale.
edited 17 Jul 2026 by Dr_Bram_Verhoeven — updated for the 2026 guidance change
The short version: U-100 only, smallest barrel that fits the dose, read the leading edge of the plunger stopper.
A 2 mm air bubble in a 0.3 mL barrel is about 4 microlitres, which against a 10-unit (100 microlitre) draw is a four per cent error. Flick it to the hub and expel it before reading.
Graduation intervals by barrel size are printed on the packaging and are the practical limit on dosing resolution.
Half-graduation estimation is not measurement. If the dose needs it, change the concentration instead.
Read the leading edge of the stopper, every time.
A dose that lands below about five units on any barrel is being measured too coarsely and the reconstitution should be redone.
Fixed-needle insulin syringes retain roughly 3 to 5 microlitres after the plunger bottoms out. Detachable-needle luer syringes retain 35 to 100 microlitres depending on hub design — an order of magnitude more.
Fixed needle, not detachable, unless you have a specific reason.
Ask PeptideStack is a static archive. Posting is closed, but the norms are worth stating: answer the question that was asked, show your working, cite the trial or the certificate, and say plainly where the evidence runs out.